Product ID:EXTRA RANGE TWO-CYCLE ENGINE OIL, 21-607
MSDS Date:01/18/1990
FSC:9150
NIIN:00N035332
MSDS Number: BQCKB

CITGO PETROLEUM CORP

TULSA, OK 74102
US

Emergency Phone: 318-491-6215;800-424-9300(CHEMTREC)

Info Phone: 918-495-5933

Cage: 7X110

CITGO PETROLEUM CORP

3758 TULSA, OK 74102 US

Telephone: 918-495-5933

Cage: 7X110

MINERAL OIL PETRO DISTILLATES,SOLV-REFINED(SEVERE)HEAVY

CAS: 64741-96-4

RTECS: PY8040001

Fraction By Weight: 60-80%

MINERAL SPIRITS

CAS: 64475-85-0

Fraction By Weight: <25%

ASHLESS DISPERSANT AND ANTI-OXIDANT

Fraction By Weight: 5-15%

RUST INHIBITOR

Fraction By Weight: <1%

DYE

CAS: 109125-50-0

Fraction By Weight: <1%

PNEUMONIA. SUBCUTANEOUS OR INTRAMUSCULAR

RTECS: 9999999ZZ

FAMILIAR WITH TECHNIQUE, SEEK SKILLED ADVICE.

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:INHAL: LOW RISK OF INHAL. IN
ENCLOSED SPACES/WHEN HOT, VAPS MAY REACH CONC SUFFICIENT TO CAUSE
DROWS, DIZZ, HDCH, NAUS/LUNG IRRIT. MISTS ABOVE TLV MAY CAUSE CHEM
PNEUMONITIS. SKIN/EYE: MILD IRRI T. INGEST:TOX IS RELATIVELY LOW,
HOWEVER, OF A SAYBOLT VISCOSITY OF ABOUT 200C, THERE EXISTS STILL
SOME(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:RISK OF ASPIR INTO LUNGS. ON INGEST OF
LRG QTYS, SLIGHT GI DISCOMFORT, DIARR, & HDCH MAY OCCUR. SMALL
DOSES MAY PRODUCE IRRIT & DIARR.
INJECTION:SUBCUTANEOUS/INTRAMUSCULAR INJECTION SHOULD BE
CONSIDERED AS A MED EMERGECNY. CHRONIC:PRLNGD &/OR FREQUENT DERMAL
CNTCT MAY CAUSE DRYING, CRACKING (DERM)(SUPP DATA)
Medical Cond Aggravated by Exposure:NONE.

First Aid:INHAL:REMOVE TO FRESH AIR. RESP SUPPORT, IF NEC. SEEK MEDICAL
AID. SKIN: WASH W/SOAP & WATER. DO NOT WEAR HEAVILY CONTAM CLTHG
BEFORE LAUNDERING. EYES: FLUSH W/LARGE VOLUMES OF WATER. SEEK
PHYSICIAN I F ANY COMPLICATIONS ARISE. INGEST: DO NOT INDUCE
VOMITING. SEEK MED AID. INJECTION:SUBCUTANEOUS INJECTION IS A MED
EMERGECNY. SEEK MED AID IMMED. NOTE TO MD: FOLLOWING INGEST, AT A
SAYBOLT (SUPP DATA)

Flash Point Method:COC
Flash Point:165F,74C
Lower Limits:1.0%
Upper Limits:6.0%
Extinguishing Media:CO*2, DRY CHEMICAL, FOAM, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:WATER MAY CAUSE FROTHING.

Spill Release Procedures:REMOVE SOURCES OF HEAT/IGNIT, PROVIDE ADEQ
VENT, CONTAIN LEAK. SMALL SPILLS:ABSORB W/SUITABLE MATERIAL SUCH AS
RAGS, STRAW OR SAND. LARGE SPILLS: CONTAIN SPILL IN EARTHEN DIKES
FOR LATER RECOVERY. REP ORT SPILLS AS REQUIRED TO APPROPRIATE
AUTHORITIES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE <150F. DO NOT APPLY HIGH HEAT OR
FLAME TO CONTAINER. KEEP SEPARATE FROM STRONG OXIDIZNG AGENTS.
Other Precautions:CAUTION:EMPTY CNTNTS MAY CONTAIN PROD RESIDUE WHICH
COULD INCL FLAMM/EXPLO VAPS. CONSULT APPRO FED, STATE & LOCAL
AUTHORITIES BEFORE REUSING, RECONDITIONING, RECLAIMING, RECYLING OR
DISPOSING OF EMPTY CNTNRS &/OR WASTE RESIDUES OF PRODUCT.

Respiratory Protection:NORMALLY NONE REQUIRED. IF HIGH VAPOR OR MIST
CONCENTRATIONS EXPECTED, USE NIOSH/MSHA APPROVED RESPIRATOR
APPROVED FOR ORGANIC VAPORS AND MISTS.
Ventilation:NONE SPECIFIED BY MANUFACTURER.
Protective Gloves:OIL IMPERVIOUS GLOVES. (POLYMER GLOVES)
Eye Protection:CHEMICAL WORKERS GOGGLES .
Other Protective Equipment:WEAR BODY-COVERING WORK CLOTHES TO AVOID
PROLONGED OR REPEATED EXPOSURE.
Work Hygienic Practices:LAUNDER SOILED WORK CLOTHES BEFORE REUSE. WASH
EXPOSED SKIN THOROUGHLY WITH SOAP AND WATER.
Supplemental Safety and Health
EFTS OF OVEREXP:OR FOLLICULITIS. RPTD EXCESSIVE EXPOSURE TO MISTS/FUMES
MAY INDUCE PULMONARY IRRIT OR CHRONIC BRONCHITIS. FIRST AID PROC:
VISCOSITY OF ABOUT 200C, THERE EXIST STILL SOME RISK OF ASPIR INTO
LNGS. REMOVAL BY CUFFED TUBE LAVAGE MAY BE CONSIDERED. ASPIR MATLS
MAY CAUSE CHEM PNEUMONITIS/LIPOID (ING 6)

HCC:V4
Boiling Pt:B.P. Text:>300F,>149C
Vapor Pres:<20
Vapor Density:>1
Spec Gravity:0.86 (H*2O=1)
Evaporation Rate & Reference:<1 (BUTYL ACETATE=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:BLUE LIQUID, SLIGHT ODOR OF PETROLEUM DISTILLATE
Percent Volatiles by Volume:<25

Stability Indicator/Materials to Avoid:YES
STRONG OXIDANTS.
Stability Condition to Avoid:NONE
Hazardous Decomposition Products:CO*2, (CO UNDER INCOMPLETE
COMBUSTION).

Waste Disposal Methods:IT IS THE RESPONSIBILITY OF THE USER TO
DETERMINE IF THE MATL IS A HAZ WASTE @ TIME OF DISP. CHECK BEFORE
DISP TO BE SURE YOU ARE IN COMPLIANCE W/ALL APPLIC FED, STATE, &
LOC LAWS & REGS. CHEMTREC/RCR A EMERGENCY HOTLINE #:800-424-9346.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.